Page 1 of 52 PIN NUMBER: 0558CN1404 Rev 3 Fire River™ TECHNICAL MANUAL & USER HANDBOOK [With Battery Operated Remote] For use with Natural
Page 10 of 52 General Installation Information This fire is intended for decorative purposes. The installation must be in accordance with National
Page 11 of 52 This fire needs an air vent within the room which will provide a minimum of 100cm2 free air in accordance with National Regulations. I
Page 12 of 52 Building and Installation Work All building and gas installation should be carried out by a qualified and competent person, and must a
Page 13 of 52 Gas Supply Consult the Data Plate within the appliance to ensure the correct gas type and pressure is available within the property
Page 14 of 52 Room Ventilation This fire needs an air vent supplying a minimum of 100cm2 free air into the room from outside. The air vent must co
Page 15 of 52 Front & Side View
Page 16 of 52 Installing the Enclosure This fire is supplied with an enclosure and integral burner. The appliance is supplied with a fully tested a
Page 17 of 52 Gather Unit If the standard gather is not used, the flue must be connected to the enclosure in accordance with GAS SAFE and local r
Page 18 of 52 Fitting the Magic Eye (Metal Version) The magic eye must be the correct way round (as shown above) to ensure “line of sight” and
Page 19 of 52 Fitting the Metal Fascia The trim is optional and can be fitted after the fire is completed by using the two lower and two upper scre
Page 2 of 52 Contents Page 3 Technical Data Page 4 READ THIS FIRST Page 5 Unpacking the Appliance Page 6 Parts List Page 7 Construction
Page 20 of 52 COMMISSIONING THE APPLIANCE WARNING: The burner inlet flow rates are factory set and sealed. Under no circumstances should these set
Page 21 of 52 • Now light all other gas appliances in the home and run tests 1-3 again. • Record your results in the check sheet. • THE PRESSURE
Page 22 of 52 • The customer must be told not to block the room air vent. • The warranty card is to be completed by the registered engineer who ha
Page 23 of 52 CVO Commissioning Checklist Important Notice Explain the operation of the appliance to the end user, hand the completed instruction
Page 24 of 52 Oxygen Depletion Pilot System There is a highly sensitive oxygen depletion sensor designed into the pilot light. If any part is dama
Page 25 of 52 Burner Flame The flame on this type of appliance is normally directed towards the rear of the enclosure. This is normal due to the op
Page 26 of 52 Fault Diagnosis/Troubleshooting Every CVO fire is tested in the factory and give a 40 point check to ensure it operates correctly. I
Page 27 of 52 Symptom Check List Tick The system “beeps” all the time. There is a fault diagnosis system built into the battery remote. The remote
Page 28 of 52 Remote Control Components
Page 29 of 52 Battery Remote System – Alarm Sequence This fire is operated via a battery remote system with AA batteries. The remote system has a b
Page 3 of 52
Page 30 of 52 Service and Aftercare Requirements When completing the annual service of the unit, refer to the enclosed technical installation and
Page 31 of 52 Servicing Procedure • Turn off the fire and allow cooling time. • Turn off the gas supply at the isolation tap. • Remove the fa
Page 32 of 52 Exchangeable Components List CVO Part Code Item Description Gas Type Code Number Qty per Fire Engineer Exchange Parts User Exchange
Page 33 of 52 Fitting Spare Parts The only “user” replacement part for this gas fire is the remote handset. All other parts must be fitted by a tra
Page 34 of 52 Fitting the Optional Wall Switch Important This work must be carried out by a GAS SAFE REGISTERED ENGINEER.
Page 35 of 52 Remote Diagram Take some time to review the attached diagram NOTE THE POSITION OF THE “LINK”
Page 36 of 52 INSTRUCTIONS • Use the gas isolation valve to isolate the gas. • Taking care not to damage any components on the circuit board remo
Page 37 of 52 Converting the Fire To Mains Supply This must be done by a GAS SAFE Engineer and trained electrician. 1. Parts Required: a. Mains
Page 38 of 52
Page 39 of 52 PIN NUMBER: 0558CN1404 Rev 3 Fire River™ USER HANDBOOK [With Battery Operated Remote]
Page 4 of 52 READ THIS FIRST This appliance is supplied as a complete suite of enclosure of gas fire burner unit, enclosure and fascia. To comply w
Page 40 of 52 Contents Page 41 General Information Page 42 Lighting the Fire - Start/Shutdown Instructions Page 45 Using the Manual Switch [if
Page 41 of 52 General Information A qualified GAS SAFE registered installer is required to fully install the appliance, failure to do this may ren
Page 42 of 52 Appliance Start Up / Shut Down Instructions (Lighting the Fire) The appliance is supplied with an internal battery power supply and i
Page 43 of 52 • To Summarise: o Button #1 & #2 together – This switches the appliance ON. o Button #1 – This switches the appliance OFF a
Page 44 of 52 Infra-Red Remote Operation Infrared systems require “Line of sight” between the handset and the sensor at the appliance, it is a stand
Page 45 of 52 Lighting the fire with the Manual Switch. There is an optional wall switch. This is a manual switch membrane which can be stuck to th
Page 46 of 52 How to Shutdown the fire if the Handset is Faulty or Lost while the Fire is Lit The appliance has a safety shut down switch which is
Page 47 of 52 Replacing the Batteries Main Appliance Batteries To ensure a long life use a set of brand new lithium batteries. Always replace all 6
Page 48 of 52 Hand Set Batteries Turn over the hand set and unclip the battery cover. Fit a new 9V battery and refit the battery cover. The applian
Page 49 of 52 Wax Never place candles on the burner shelves. If molten wax enters the burner unit – DO NOT USE THE APPLIANCE - contact your instal
Page 5 of 52 Unpacking the Appliance Read these instructions fully before proceeding. Carefully examine the carton for damage before proceeding.
Page 50 of 52 WARRANTY INFORMATION This appliance carries full CE approval and has a long and reliable history. The CE approval ensures that, if in
Page 51 of 52
Page 52 of 52 ONLY USE GENUINE REPLACEMENT PARTS. Spirit Fires Ltd, 4 Beaumont Square Aycliffe Industrial Park, Newton Aycliffe County Durham,
Page 6 of 52 Fire River Parts List Parts List • Fire is supplied as a Kit: o Brushed Steel Enclosure. o Front Shelf. o Burner Unit with Remot
Page 7 of 52 Construction Dimensions
Page 8 of 52 Gas Burner Construction Take some time to review the burner construction taking note of the positions of the main components and the
Page 9 of 52 Remote Control System Take some time to learn about the remote system fitted to this fire. This is operated by a fully sequential bat
Comments to this Manuals